The Requirements of 40 CFR 265.33 Testing and Maintenance of Equipment for Generators of Hazardous Waste

The Requirements of 40 CFR 265.33 Testing and Maintenance of Equipment for Generators of Hazardous Waste

In the previous article of this series I described the requirements of 40 CFR 265.32 – Required equipment.  That section identified the equipment (communication, spill response, and fire suppression) required of applicable facilities (LQGs and SQGs).

This article is the fourth in a series that will look closely at each section of 40 CFR 265, Subpart C and explain its requirements, how they apply to generators of hazardous waste, and what is required for compliance.  Keep in mind that the regulations of your State may differ from these Federal regulations.

The purpose of this article: identify and explain the requirements of 40 CFR 265.33 – Testing and maintenance of equipment for generators of hazardous waste under the emergency preparedness and prevention regulations of 40 CFR 265, subpart C.

Hold on a minute!  These regulations were revised and moved to a new location within Title 40 of the CFR by the Generator Improvements Rule.  If your state has not yet adopted the Generator Improvements Rule, then this article is still applicable to you (but it won’t be for much longer).  If your state has adopted and been authorized to enforce the Generator Improvements Rule, then these regulations no longer apply to you.  Read: What is the status of the Generator Improvements Rule in my state?

To see an explanation of these regulations as revised by the Generator Improvements Rule you must refer to the following:

Not sure of your hazardous waste generator category?

Take this short survey

To see an explanation of the regulations prior to the revisions of the Generator Improvements Rule, please continue reading this article.

40 CFR 265.33 reads:

All facility communications or alarm systems, fire protection equipment, spill control equipment, and decontamination equipment, where required, must be tested and maintained as necessary to assure its proper operation in time of emergency.

Interested in a Webinar that covers this topic, and more!

My Webinar Training Schedule

As stated earlier, §265.32 identified the equipment required of an LQG or SQG, including:

  • Internal and external communication devices.
  • Fire fighting equipment.
  • Spill control and decontamination equipment.
  • Water at sufficient volume to supply fire fighting systems.

This section requires the testing and maintenance of that equipment.  Note the following:

  • The regulations take into account the fact that some equipment may not be required in §265.32 and therefore does not require testing and maintenance.
  • The type and frequency of testing and maintenance is intentionally not defined by the USEPA, “…tested and maintained as necessary…”.  This is due to the variety of systems and equipment encompassed by these regulations (communication, alarm, fire, spill control, etc.).  It is up to you as the owner of the facility to determine compliance based on guidance from the equipment manufacturer, industry standards, your insurance provider, Fire Marshall, and if applicable, OSHA standards.
    Emergency phone

    Tested and maintained?

  • Though the regulations do not require the maintenance of a record for a specified period of time to demonstrate compliance as it does for other RCRA Regulations (Read:  Recordkeeping Requirements of RCRA), it is a good idea to maintain some form of a record and make it available upon inspection if necessary.
  • A frequent occurrence in industry is the slow erosion of spill control and decontamination equipment reserved for emergencies as it is consumed for routine spills and housekeeping.  Communicate and enforce policies to ensure emergency equipment is only used in emergencies.  Other resources should be made available to employees to provide equipment for non-emergency clean-ups.  In addition, routine inspections (perhaps weekly with your inspection of hazardous waste accumulation areas) is a good way to ensure necessary emergency equipment is available.

This section expands upon the regulations of 40 CFR 265.32 to have the necessary emergency equipment to require you to maintain that equipment in a state of readiness for any emergency that may occur at your facility.

Look for my next article in this series where I’ll take a close look at 40 CFR 265.34 – Access to communications or alarm systems.

Contact me with any questions you may have about the generation, identification, management, and disposal of hazardous waste

Daniels Training Services, Inc.

815.821.1550

Info@DanielsTraining.com

https://www.danielstraining.com/

Please contact me to discuss the requirements of 40 CFR 265, Subpart C – Preparedness and prevention, the training requirements for facility personnel, or any other questions you may have about the management of hazardous waste.